Dynamic Characteristic Analysis of Capacitive High Bore Pressure Tester
-
摘要: 由于在压力的激励下新型电容式高膛压测试仪壳体产生的振动特性将影响测试仪的动态特性,因此着重研究了测试仪壳体的动力学特性,建立了壳体受外压作用时的动力学模型。理论计算表明,壳体径向振动的一阶振动频率在75 kHz以上,而火炮膛压的频谱在5 kHz以下,说明壳体振动对膛压测试精度的影响可以忽略。Abstract: According to the dynamic characteristics of a new capacitive high bore pressure tester, which is decided by the vibration characteristics of the pressure tester shell subjected to pressure, the dynamic model of the tester shell under external pressure was established, and the dynamic properties of the tester shell were studied.The calculation results show that the first vibration frequency of shell radial vibration is above 75 kHz, and the frequency spectrum of the bore pressure is below 5 kHz.Consequently, the influence of shell vibration on the test precision of bore pressure can be ignored.
-
Key words:
- pressure /
- dynamic properties /
- chamber pressure measurement
-
表 1 压力测试仪整体结构的径向振动频率
Table 1. The radial vibration frequency of the whole structure of pressure tester
Exponent number Frequency/(kHz) 1 75.458 2 616.385 3 1 224.886 4 1 835.178 5 2 445.904 6 3 056.802 7 3 667.787 8 4 278.820 -
[1] 张艳玲, 柳光辽.火炮膛压峰值的计算机测试系统[J].弹道学报, 1998, 10(2): 78-81.Zhang Y L, Liu G L. A computer test system of gun peak chamber pressure[J]. Journal of Ballistics, 1998, 10(2): 78-81. (in Chinese) [2] 张记龙, 路宏年, 任树梅.武器膛压测试传感器动态响应误差分析方法[J].太原机械学院学报, 1993, 14(1): 22-26.Zhang J L, Lu H N, Ren S M. The dynamic response error in chamber pressure measurement[J]. Journal of Taiyuan Institute of Machinery, 1993, 14(1): 22-26. (in Chinese) [3] 祖静, 张志杰, 裴东兴, 等.新概念动态测试[J].测试技术学报, 2004, 18(增): 1-9.Zu J, Zhang Z J, Pei D X, et al. New concept dynamic test[J]. Journal of Test and Measurement Technology, 2004, 18(Supplement): 1-9. (in Chinese) [4] 李新娥, 祖静, 徐鹏.新型应变式高膛压测试系统研制[J].高压物理学报, 2011, 25(4): 310-316.Li X E, Zu J, Xu P. A novel strain type high chamber pressure test system[J]. Chinese Journal of High Pressure Physics, 2011, 25(4): 310-316. (in Chinese) [5] 杨桂通.弹性力学[M].北京: 高等教育出版社, 2005.Yang G T. Elastic Mechanics[M]. Beijing: Higher Education Press, 2005. (in Chinese) [6] 蒋学东, 李小平.厚壁圆筒在动载荷作用下的应力分析[J].江苏工业学院学报, 2004, 16(3): 8-13.Jiang X D, Li X P. Analysis of the stress created by sudden load in the cylinder[J]. Journal of Jiangsu Polytechnic University, 2004, 16(3): 8-13. (in Chinese) [7] 孔德仁, 朱明武, 申爱平, 等.铜柱测压器动态特性分析及计算机仿真[J].火工品, 2001(2): 27-30.Kong D R, Zhu M W, Shen A P, et al. Dynamical characteristics analysis of copper cylinder crusher gauge and computer simulation[J]. Initiators & Pyrotechnics, 2001(2): 27-30. (in Chinese) [8] 倪振华.振动力学[M].西安: 西安交通大学出版社, 1990.Ni Z H. Vibration Mechanics[M]. Xi'an: Xi'an Jiaotong University Press, 1990. (in Chinese)