-
摘要: 海参的超高压处理与传统的处理方法相比有许多优越性,具有十分广阔的应用前景。研究了超高压处理过程中压力(0.1~550 MPa)、保压时间(0~30 min)、温度(24~62 ℃)及保压方式对海参自溶酶活性的影响。在室温、保压20 min的条件下,200 MPa左右较低压力下酶活性降低,相对残存活性为88.25%;250 MPa较高压力下自溶酶被激活,酶活性为106.77%;550 MPa高压下酶活性最低为29.81%。自溶酶活性随保压时间和温度的增加先上升后下降;保压方式对自溶酶活性的影响不大。同时利用误差反向传播神经网络(Back Propagation Neural Network,BP人工神经网络),模拟了超高压钝酶效果,与实验结果比较,平均相对误差为0.9%,可以获得较好的预测结果。研究结果表明,在一定的压力、保压时间和温度下,酶被激活,其活性上升;而在一定的压力、保压时间和温度下,酶被钝化,活性降低。对优化海参超高压钝酶工艺具有一定的参考价值。Abstract: The high hydrostatic pressure treatment on sea cucumber has many advantages over traditional processes and it has a promising future. Effects of processing parameters on holothurians autoenzyme activity were investigated within the range of the parameters: the processing pressure of 0.1~550 MPa, the pressure-keeping time of 0~30 min, the processing temperature of 24~62 ℃. Under the room temperature and pressure-keeping time of 20 min, the autoenzyme activity decreased to 88.25% at 200 MPa, increased to 106.77% at 250 MPa, and reached the lowest level of 29.81% at 550 MPa. The holothurians autoenzyme activity increased first and then decreased with the increasing of pressure-keeping time and temperature. The effect of pressure-keeping mode on holothurians autoenzyme activity was not significant. The BP artificial neural network was used to predict the effects of high pressure on holothurians autoenzyme. Compared with the experimental results, the average relative error of predicted results was 0.9%. The experimental results show that the holothurians autoenzyme can be activated and inactivated at certain pressure, pressure-keeping time and temperature. The study provides some valuable information for optimizing the high hydrostatic pressure treatment of holothurians autoenzyme inactivation.
-
Wu R P, Chen Y, Fang J R, et al. Studies on the Chemical Constituents from Sea Cucumber Mensamaria Intercedens Ⅳ Isolation, Propreties and Antitumor Activity of the Glycoprotein from Mensamaria Mntercedens [J]. Chinese Journal of Marine Drugs, 2000, 19(5): 4-6. (in Chinese) 吴萍茹, 陈粤, 方金瑞, 等. 二色桌片参的化学成分研究Ⅳ二色桌片参糖蛋白的分离性质及抗肿瘤活性的研究 [J]. 中国海洋药物, 2000, 19(5): 4-6. Huang Y L, Zheng Z H, Su W J, et al. Studies on the Chemical Composition of Sea Cucumber Mensamaria Intercedens Ⅲ. Immunomodulative Effects of PMI-1 [J]. Marine Science Bulletin, 2001, 20 (1): 88-91. (in Chinese) 黄益丽, 郑忠辉, 苏文金, 等. 二色桌片参的化学成分研究: Ⅲ二色桌片参多糖-1--岩藻聚糖的免疫调节作用 [J]. 海洋通报, 2001, 20 (1): 88-91. Maier M S, Roccatagliata A J, Kuriss A, et al. Two New Cytotoxic and Virucidal Trisulfated Triterpene Glycosides from the Antarctic Sea Cucumber Staurocucumis Liouvillei [J]. J Nat Prod, 2001, 64(6): 732-736. Rodriguez E, Gonzalez M, Caride B, et al. Nutritional Value of Holothuria Forskali Protein and Effects on Serum Lipid Profile in Rats [J]. J Physiol Biochem, 2000, 56(1): 39-43. Pacheco R G, Vicente C P, Zancan P, et al. Different Antithrombotic Mechanisms among Glycosaminoglycans Revealed with a New Fucosylated Chondroitin Sulfate from an Echinoderm [J]. Blood Coagul Fibrinolysis, 2000, 11(6): 563-573. Shen H, Chen J, Li H, et al. Progress of Studies on the Culture Techniques of Sea Cucumber Worldwide [J]. Hebei Fisheries, 2007, (6): 3-5. (in Chinese) 沈辉, 陈静, 李华, 等. 国内外海参养殖技术研究概况 [J]. 河北渔业, 2007, (6): 3-5. Zhu B W, Han B. Characterization and Purification of Holothurians Autoenzyme [J]. Food and Fermentation Industries, 2004, 30(4): 132-137. (in Chinese) 朱蓓薇, 韩冰. 海参自溶酶的分离纯化和部分性质研究 [J]. 食品与发酵工业, 2004, 30(4): 132-137. Anese M, Nicoli M C, Dallpaglio G, et al. Effect of High Pressure Treatments on Peroxidase and Polyphenoloxidase Activities [J]. J Food Biochemistry, 1995, 18(4): 285-293. Hendrickx M, Ludikhuyze L, Van den Broeck I, et al. Effects of High Pressure on Enzymes Related to Food Quality [J]. Trends in Food Science Technology, 1998, 9(5): 197-203. Gomes M R A, Ledward D A. Effect of High-Pressure Treatment on the Activity of Some Polyphenoloxidases [J]. Food Chemistry, 1996, 56(1): 1-5. Zeng Q M, Pan J, Xie H M, et al. Effect of High Pressure (HP) Treatments on Polyphenoloxidase (PPO) Activity in Pear Juices [J]. Chinese Journal of High Pressure Physics, 2004, 18(2): 144-148. (in Chinese) 曾庆梅, 潘见, 谢慧明, 等. 超高压处理对多酚氧化酶活性的影响 [J]. 高压物理学报, 2004, 18(2): 144-148. Gao Y L, Wang Y X, Jiang H H. Optimization of Inactivation Conditions of High Hydrostatic Pressure Using Response Surface Methodology [J]. Scientia Agricultura Sinica, 2004, 37(10): 1544-1549. (in Chinese) 高瑀珑, 王允祥, 江汉湖. 超高压杀菌条件的响应曲面法优化研究 [J]. 中国农业科学, 2004, 37(10): 1544-1549. Gao Y L, Wang Y X, Jiang H H. Optimization of Conditions to Sterilize Staphyloccus Aureus by Ultra-High Hydrostatic Pressure Using Response Surface Methodology [J]. Chinese Journal of High Pressure Physics, 2004, 18(3): 273-278. (in Chinese) 高瑀珑, 王允祥, 江汉湖. 响应曲面法优化超高压杀灭金黄色葡萄球菌条件的研究 [J]. 高压物理学报, 2004, 18(3): 273-278. Huang X D, Pan J, Xie H M, et al. Effects of Bacteria Concentration on Sterilization of Escherichia Coli in High Pressure Process [J]. Food Science, 2007, 28(2): 169-173. (in Chinese) 黄训端, 潘见, 谢慧明, 等. 菌液浓度对大肠杆菌超高压杀灭效果的影响 [J]. 食品科学, 2007, 28(2): 169-173. Otero L, Antonio D, Molina G. A Model for Real Thermal Control in High-Pressure Treatment of Foods [J]. Biotechnol Prog, 2002, 18(4): 904-908. Torrecilla J S, Otero L, Sanz P D. A Neural Network Approach for Thermal/Pressure Food Processing [J]. Journal of Food Engineering, 2004, 62(1): 89-95. Yu S, Wang H X, Ma Y J. Three-layer BP Network Model for Estimation of Casualties in an Earthquake [J]. Journal of Earthquake Engineering and Engineering Vibration, 2005, 25(6): 113-117. (in Chinese) 于山, 王海霞, 马亚杰. 三层BP神经网络地震灾害人员伤亡预测模型 [J]. 地震工程与工程振动, 2005, 25(6): 113-117.
点击查看大图
计量
- 文章访问数: 11116
- HTML全文浏览量: 518
- PDF下载量: 892