地下管廊在燃气爆炸作用下的动力响应分析

刘希亮; 李烨; 王新宇; 郭佳奇

doi:10.11858/gywlxb.20180544

地下管廊在燃气爆炸作用下的动力响应分析

doi: 10.11858/gywlxb.20180544

刘希亮^{1, 2, 3,},
李烨^1,*, ,,
王新宇^{1, 2, 3},
郭佳奇^{1, 2, 3}

1.
河南理工大学土木工程学院, 河南焦作 454000
2.
河南省地下工程与灾变防控重点实验室, 河南焦作 454000
3.
河南省地下空间开发及诱发灾变防治国际联合实验室, 河南焦作 454000

基金项目:

国家自然科学基金 51474097

河南理工大学青年骨干教师资助计划 2017XQG-08

详细信息

作者简介:
刘希亮(1964-), 男, 博士, 教授, 主要从事岩土工程、结构工程方面的研究. E-mail:xlliu@hpu.edu.cn

通讯作者:
李烨(1994-), 女, 硕士, 主要从事岩土工程方面的研究. E-mail:smartliye@sina.com

中图分类号: X932
计量
- 文章访问数: 8313
- HTML全文浏览量: 2780
- PDF下载量: 14
出版历程
- 收稿日期: 2018-04-23
- 修回日期: 2018-05-31

Dynamic Response Analysis of Underground Pipe Gallery under Gas Explosion

LIU Xiliang^{1, 2, 3
,},
LI Ye^{1,*
, ,},
WANG Xinyu^{1, 2, 3},
GUO Jiaqi^{1, 2, 3}

1.
School of Civil Engineering, Henan Polytechnic University, Jiaozuo 454000, China
2.
Key Laboratory of Henan Province for Underground Engineering and Disaster Prevention, Jiaozuo 454000, China
3.
International Joint Research Laboratory of Henan Province for Underground Space Development and Disaster Prevention, Jiaozuo 454000, China

摘要

摘要: 在燃气通过地下管廊输送过程中，若燃气泄漏进入管廊内部并引起爆炸将会产生严重的后果。以平潭综合试验区环岛路管线工程为背景，借助LS-DYNA非线性动力分析有限元软件，基于流固耦合和ALE多物质算法，建立地下空间燃气爆炸数值计算模型，探讨管廊内燃气爆炸过程中爆炸冲击波对管廊结构的影响。数值计算结果表明：在爆炸过程中，超压峰值从爆源中心转移到波阵面上，导致爆源附近压力低于波阵面压力，爆源附近形成负压区；爆炸荷载作用下，燃气仓内距离爆源最近的内墙上的测点超压值最大，在t=7.8 ms时达到最大值为18.65 MPa，且在t=10 ms左右时，位移和速度达到最大值，分别为10.47 mm、3.303 m/s；气体爆炸后，管廊燃气仓内墙正负压振荡时间持续较长，振动现象最为明显，最易发生破坏。
- 地下管廊 /
- 气体爆炸 /
- 数值模拟 /
- 流固耦合 /
- ALE多物质算法
Abstract: Many factors can cause natural gas explosions, and it will lead to serious structural damages and human injures.This study is focused on the leakage of natural gas from underground pipe gallery.A case study has been made in a project of the circular island road in Pingtan comprehensive test.An underground explosion was modeled by use of the fluid-solid coupling and multi-material ALE algorithm in finite element software LS-DYNA.On this basis, the influence of explosion shock wave on the surrounding structure was discussed.Numerical results show that, during the whole process of the explosion, the overpressure transferred from explosion source center to the wave front, leading to the lower pressure in the explosion source compared to the wave front and the formation of a negative pressure zone near the explosion source.The overpressure value of point which is on the internal wall closest to the explosion source in the gas cabin is larger than that of other points.The maximum overpressure is 18.65 MPa at t=7.8 ms.At t=10 ms, the displacement and velocity reach their own maximum values of 10.47 mm and 3.303 m/s, respectively.Explosion in the gas cabin, interior wall experiences positive and negative pressure oscillation with long duration, the vibration phenomenon is most obvious and the structure is easy to be failure.
- underground pipe /
- gas explosion /
- numerical simulation /
- fluid-solid coupling /
- multi-material ALE algorithm

HTML全文

图 1 有限元模型

Figure 1. Finite element model

下载: 全尺寸图片幻灯片

图 2 管廊内冲击波超压云图

Figure 2. Overpressure contour of shock wave in gallery at different simulation times

下载: 全尺寸图片幻灯片

图 3 管廊结构所受压力云图

Figure 3. Pressure contour of gallery structure at different simulation times

下载: 全尺寸图片幻灯片

图 4 xOy面数据采集点位置示意图

Figure 4. Schematic diagram of data acquisition points in the xOy plane

下载: 全尺寸图片幻灯片

图 5 各节点超压时程曲线变化图

Figure 5. Time history diagram of node overpressure

下载: 全尺寸图片幻灯片

图 6 数据采集点位置示意图

Figure 6. Position diagram of data acquisition points

下载: 全尺寸图片幻灯片

图 7 各节点超压时程曲线

Figure 7. Time history diagram of node overpressure

下载: 全尺寸图片幻灯片

图 8 节点位移时程曲线变化图

Figure 8. Time history diagram of node displacement

下载: 全尺寸图片幻灯片

图 9 节点速度时程曲线变化图

Figure 9. Time history diagram of node velocity

下载: 全尺寸图片幻灯片

表 1 土壤材料参数

Table 1. Parameters of soil material

Material	Thickness/ cm	Density/ (g·cm^-3)	Cohesion/ kPa	Internal frictionangle /(°)	Elastic modulus/MPa	Poisson'sratio
Plain fill	130	1.8	6	10	4.2	0.30
Fully weathered granite	210	1.9	20	25	20	0.24
Sandy weathered granite	620	2.0	30	32	54000	0.21

下载: 导出CSV

表 2 混凝土材料参数

Table 2. Parameters of concrete

Density/(g·cm^-3)	Elastic modulus/GPa	Poisson's ratio	Yield strength/MPa	Shear modulus/GPa
2.5	30	0.22	33.8	12.5

下载: 导出CSV

表 3 线性多项式状态方程参数^[12]

Table 3. Parameters for linear polynomial equation of state^[12]

Material	ρ/(mg·cm^-3)	C₀/MPa	C₁	C₂	C₃	C₄	C₅	C₆	E₀/(MJ·m^-3)	V₀
Air	1.234	-0.1	0	0	0	0.400	0.400	0	0.250	1.0
CH₄-Air	1.293	0	0	0	0	0.274	0.274	0	3.408	1.0

下载: 导出CSV

参考文献(13)

[1]	雷升祥.综合管廊与管道盾构[M].北京:中国铁道出版社, 2016. LEI S X.Utility tunnel and pipeline shield[M]. Beijing:China Railyway Press, 2016.
[2]	陈国华, 吴家俊.地下密闭空间燃气爆炸冲击波传播规律[J].天然气工业, 2017, 37(2):120-125. http://d.old.wanfangdata.com.cn/Periodical/trqgy201702016 CHEN G H, WU J J.Propagation laws of gas explosion shock waves in underground confined space[J]. Nature Gas Industy, 2017, 37(2):120-125. http://d.old.wanfangdata.com.cn/Periodical/trqgy201702016
[3]	路长, 李毅, 潘荣锟.管道氢气-空气预混气体爆炸特征的试验研究[J].安全与环境学报, 2016, 16(3):38-41. http://d.old.wanfangdata.com.cn/Periodical/aqyhjxb201603009 LU C, LI Y, PAN R K.Experimental study on explosion tendency of hydrogen-air premixed gases in the duct[J]. Journal of Safety and Enviroment, 2016, 16(3):38-41. http://d.old.wanfangdata.com.cn/Periodical/aqyhjxb201603009
[4]	秦波涛, 张雷林, 王德明, 等.采空区煤自燃引爆瓦斯的机理及控制技术[J].煤炭学报, 2009, 34(12):1655-1659. doi: 10.3321/j.issn:0253-9993.2009.12.013 QIN B T, ZHANG L L, WANG D M, et al.Mechanism and restraining technology on spontaneous combustion of coal fetonating gas in goaf[J]. Journal of China Coal Society, 2009, 34(12):1655-1659. doi: 10.3321/j.issn:0253-9993.2009.12.013
[5]	卢捷, 宁建国, 王成, 等.煤气火焰传播规律及其加速机理研究[J].爆炸与冲击, 2004, 24(4):305-311. doi: 10.3321/j.issn:1001-1455.2004.04.003 LU J, NING J G, WANG C, et al.Study on flame propagation and acceleration mechanism of city coal gas[J]. Explosion and Shock Wave, 2004, 24(4):305-311. doi: 10.3321/j.issn:1001-1455.2004.04.003
[6]	王成, 胡斌斌.小尺度管道中CH₄-O₂爆炸火焰传播规律实验研究[J].北京理工大学学报, 2016, 36(8):784-788. http://d.old.wanfangdata.com.cn/Periodical/bjlgdxxb201608003 WANG C, HU B B.Experimental study on the explosive flame propagation of CH₄-O₂ in small scale pipeline[J]. Transactions of Beijing Institute of Technology, 2016, 36(8):784-788. http://d.old.wanfangdata.com.cn/Periodical/bjlgdxxb201608003
[7]	左哲, 姚志强, 高进东, 等.受限空间内天然气爆炸反应过程模拟分析[J].天然气工业, 2015, 35(6):131-137. doi: 10.3787/j.issn.1000-0976.2015.06.020 ZUO Z, YAO Z Q, GAO J D, et al.Simulation analysis of natural gas explosion within confined space[J]. Nature Gas Industy, 2015, 35(6):131-137. doi: 10.3787/j.issn.1000-0976.2015.06.020
[8]	周宁, 耿莹, 冯磊, 等.点火能对气体爆炸过程及气体爆炸过程中薄壁管道应变规律的实验研究[J].高压物理学报, 2016, 30(3):202-206. http://www.gywlxb.cn/CN/abstract/abstract1871.shtml ZHOU N, GENG Y, FENG L, et al.Experimental study on the starin law of the thin-walled pipe in the gas explosion process with different ignition energies[J]. Chinese Journal of High Pressure Physics, 2016, 30(3):202-206. http://www.gywlxb.cn/CN/abstract/abstract1871.shtml
[9]	杜扬, 李国庆, 李阳超, 等.T型分支管道对油气爆炸压力的影响[J].爆炸与冲击, 2017, 37(2):323-330. http://d.old.wanfangdata.com.cn/Periodical/bzycj201702022 DU Y, LI G Q, LI Y C, et al.Effects of a T-shaped branch pipe on overpressure of gasoline-air mixture explosion[J]. Explosion and Shock Wave, 2017, 37(2):323-330. http://d.old.wanfangdata.com.cn/Periodical/bzycj201702022
[10]	蒋新生, 魏树旺, 徐建楠, 等.分支管道长度对有油田气爆炸强度影响试验研究[J].中国安全科学学报, 2017, 27(2):53-58. JIANG X S, WEI S W, XU J N, et al.Experimental study on effect of length of branch on intensity of gasoline-air mixture explosion in pipeline[J]. China Safety Science Journal, 2017, 27(2):53-58.
[11]	赵衡阳.气体和粉尘爆炸原理[M].北京:北京理工大学出版社, 1996. ZHAO H Y.The principle of gas and dust explosion[M]. Beijing:Beijing Institute of Technology Press, 1996.
[12]	吴燕燕.室内燃气爆炸作用下钢框架结构动力响应与连续倒塌分析[D].哈尔滨: 东北林业大学, 2012. http://cdmd.cnki.com.cn/Article/CDMD-10225-1012445868.htm WU Y Y.Analysis on dynamic responses and progressive collapse of steel frame structure subject to internal gas explosion[D]. Harbin: Northeast Forestry University, 2012. http://cdmd.cnki.com.cn/Article/CDMD-10225-1012445868.htm
[13]	Livermore Software Technology Corporation.LS-DYNA keyword user's manual[Z]. Livermore, CA: Livermore Software Technology Corporation, 2006.