高温处理后活性粉末混凝土动力学行为及本构模型研究

王立闻; 庞宝君; 陈勇; 张凯

doi:10.11858/gywlxb.2012.04.001

高温处理后活性粉末混凝土动力学行为及本构模型研究

doi: 10.11858/gywlxb.2012.04.001

王立闻^1,2, ,,
庞宝君¹,
陈勇¹,
张凯¹

1.
哈尔滨工业大学航天学院，黑龙江哈尔滨 150080；
2.
中国东方电气集团有限公司，四川成都 611731

详细信息

通讯作者:
王立闻 E-mail:wanglw83@yahoo.cn

计量
- 文章访问数: 6876
- HTML全文浏览量: 342
- PDF下载量: 554
出版历程
- 收稿日期: 2010-12-27
- 修回日期: 2011-01-12
- 发布日期: 2012-08-15

Study on Dynamic Mechanical Behavior and Constitutive Model of Reactive Powder Concrete after Exposure in High Temperature

1.
School of Astronautics, Harbin Institute of Technology, Harbin 150080, China;
2.
Dongfang Electric Corporation, Chengdu 611731, China

摘要

摘要: 利用分离式霍普金森压杆系统，采用铅片作为整形器，分别对常温下及400、600、800 ℃高温处理后的活性粉末混凝土（Reactive Powder Concrete，RPC）试样进行单轴冲击压缩实验，研究高温后RPC材料的动态力学性能，建立高温处理后材料的率型本构模型。结果表明：经不同高温处理后的RPC材料的动态抗压强度和韧性指标均有较明显的应变率敏感性，而峰值应变、初始弹性模量受应变率影响不大；不同应变率下，400 ℃以上高温处理后RPC材料的单轴动态压缩力学性能有所降低。扫描电镜分析表明，高温处理后RPC材料微观结构的劣化是宏观力学性能降低的根本原因。对ZWT粘弹性本构模型进行了修正，修正后的模型适用于混凝土材料经高温处理后的率型本构关系的分析。
- 分离式霍普金森压杆 /
- 活性粉末混凝土 /
- 高温 /
- 动态力学性能 /
- 本构模型 /
- 扫描电镜
Abstract: The dynamic mechanical behavior and rate constitutive model of reactive powder concrete (RPC) after exposure in high temperature are studied experimentally by means of split Hopkinson pressure bar system. Both the untreated specimens and those after exposure in high temperature (400, 600 and 800 ℃) are tested with lead flakes as pulse shapers. The experimental results show that both dynamic compressive strength and toughness of RPC after different high temperature treatments exhibit remarkable strain rate sensitivity while the peak strain and initial Young modulus do not. Furthermore, the dynamic uniaxial compressive mechanical properties of RPC at different strain rate debased after exposure at high temperature over 400 ℃. The scanning electron microscope (SEM) technology is also used to investigate the microstructure change of the RPC material; it proves that the deterioration of microstructure is the essential reason for the reduction of the RPC's macroscopic mechanical performance. In addition, ZWT viscoelastic constitutive model is utilized and modified, thus it can be used to analysis the rate constitutive relations of concrete after exposure in high temperature.
- split Hopkinson pressure bar /
- reactive powder concrete /
- high temperature /
- dynamic mechanical properties /
- constitutive model /
- scanning electron microscope

HTML全文

参考文献(13)

Richard P, Cheyrezy M. Composition of reactive powder concretes [J]. Cem Concr Res, 1995, 25(7): 1501-1511.

Ju Y, Liu H B, Sheng G H, et al. Experimental study of dynamic mechanical properties of reactive powder concrete under high-strain-rate impacts [J]. Sci China Technol Sc, 2010, 53(9): 2435-2449.

Poon C S, Shui Z H, Lam L. Compressive behavior of fiber reinforced high-performance concrete subjected to elevated temperatures [J]. Cem Concr Res, 2004, 34(12): 2215-2222.

Lau A, Anson M. Effect of high temperatures on high performance steel fibre reinforced concrete [J]. Cem Concr Res, 2006, 36(9): 1698-1707.

Felicetti R, Gambarova P G, Natali Sora M P. Mechanical behaviour of HPC and UHPC in direct tension at high temperature and after cooling [A]//Proceedings of the 5th International RILEM Symposium on Fibre-Reinforced Concrete [C]. Lyon, France, 2000: 749-758.

Tang Z P, Tian L Q, Zhu Z X, et al. Research on mechanical properties of epoxy resin at high strain rates [A]//Proceedings of the 2nd National Conference on Blast and Impact Mechanics [C]. Yangzhou, 1981. (in Chinese)

唐志平, 田兰桥, 朱兆祥, 等. 高应变率下环氧树脂的力学性能 [A]//第二届全国爆炸力学学术会议论文集 [C]. 扬州, 1981.

Wang L L. Foundation of Stress Waves [M]. 2nd ed. Beijing: National Defence Industry Press, 2005: 52-60. (in Chinese)

王礼立. 应力波基础 [M]. 第2版. 北京: 国防工业出版社, 2005: 52-60.

Taerwe L R. Influence of steel fibers on strain-softening of high-strength concrete [J]. ACI Mater J, 1993, 89(1): 54-60.

Nataraja M C, Dhang N, Gupta A P. Stress-strain curves for steel-fiber reinforced concrete under compression [J]. Cem Concr Compos, 1999, 21: 383-390.

Hu S S, Wang D R. Dynamic constitutive relation of concrete under impact [J]. Explosion and Shock Waves, 2002, 22(3): 242-246. (in Chinese)

胡时胜, 王道荣. 冲击载荷下混凝土材料的动态本构关系 [J]. 爆炸与冲击, 2002, 22(3): 242-246.

施引文献

资源附件(0)

访问统计